I have bought Bruce Palmer's book on "How to Restore Your Harley-Davidson" and I'll also buy the "How To Restore Your Military Harley-Davidson" once it is available.
At the same time I asked him whether the nuts and bolts on the UDF (SA) Harley-Davidson's were all parkerised. This was his reply:
Hello Jacques,
Mostly Parkerized. The 1941 UDF WL plating is mostly the same as a civilian 1941 WL except that many of the chrome items were painted. When I get more time, I will try to answer your other questions that came with the photographs of your 41.
The following is a list of known 1941 cadmium plated hardware pieces (does not include larger pieces such as the neck cups):
- Motor:
- tappet guide screws
- timing gear cover screws
- timing plug
- oil pump spring caps
- feed oil pump studs and nuts
- crankcase relief pipe screws.
- Carburetor:
- manifold and nuts
- lever screws
- low speed lever bolt
- bowl lock nut
- Transmission:
- shifter rod end bolt and nut
- tank shift lever stud nut
- transmission side cover screws
- Axle and Wheel: Rear axle adjusting screws.
- Brake:
- front brake and hand clutch lever pivot bolt and nut
- front brake and hand clutch cable clamp washer
- front brake and hand clutch lever bracket screws
- Front Fork:
- steering damper washer #2784-30
- steering damper large nut #2785-30
- steering damper screw #2781-37
- frame head bracket
- Frame:
- grease fittings
- control coil clamp screws
- primary chain inspection cover screws
- Fuel and Oil:
- gas valve spacer
- gas shut off knob screw
- gas shut-off rod seal cap
- oil tank drain plug
- oil line tank nipples
- vent line banjo bolt
- Electric:
- horn mounting screws #031
- horn cover bolts and nuts
- headlamp mounting washer #0228
- generator end cover screws
- spark cable packing nuts
- headlamp and horn switch cover screws
- headlamp bracket bolts #3475-36
- stop lamp switch screws
- battery terminal screws and nuts
- battery cover wing nuts
- ground wire frame screw
- frame terminal screws and nuts
- dash cover left hole plug #4518-38
- horn terminal screws
- relay mounting screws
- relay terminal screws
- front fork wire clip #4703-38A (2)
- Speedometer:
- lamp knob stem
- lamp knob screw
- Accessory: Tire pump clamp wing nuts.
Regards,
Bruce
No comments:
Post a Comment